HELP !!!!!!! then, main problem is kick start had struck and it pumping on oppositle side. If it is, run a test and make sure that you are actually getting spark. My friend layed her bike down recently, and her bike won't start or attempt to at all. I just filled my tank with apple cider vinegar, and now I am letting it sit in a tub. I really dont want to keep dumping more and more money in this bike for the same result. And when I was purchassing it from the owner it had a dead battery so we. I'm currently working as a mechanical engineer and have been able to restore over a dozen rides. And bucks and stumbles. Now it fires, there is a good starter soundthen a back fire. Bike just turns over and over but no start at all . It has been charged adequately. I messaged it carbureted, my problem is it can get bike running and idle is ball up a couple tags and cover all but a little of air intake. It has spark and the compression seems okay (about 110psi cold). But the question I have is it was all ok before the starter burned off. What else can I try?? If youre still having some issues after you go through the carbs, feel free to contact our tech team to help troubleshoot further. Hey David contact our Tech Team at 320-358-3409 or by email at techsupport@denniskirk.com and they will be able to help you troubleshoot your issue. am using yamaha scooter, fuel injector. If you do not see anything apparent and obvious, then you may need to remove your carb again and make sure everything got put back together properly. Rectifier readings are fine.help. The battery is brand new and fully charged. About three weeks now. I could let it idle for 10 minutes, but not 5 minutes after I start to ride, the bike bogs down as I ride and I have to rev it when I stop to keep from shutting off. Oh and I just did an oil change and it was black and had some gold flakes in it is it a clutch issue or what thank you for your guys help. Kickstand Is up kill switch is off. Cool little bike. If this post is about bodywork, accident damage, paint, dent/ding, questions it belongs in r/Autobody r/AutoBodyRepair/ or r/Diyautobody/ If you have tire questions check out https://www.reddit.com/r/MechanicAdvice/comments/k9ll55/can_your_tire_be_repaired/. Cannon Entities LLC is compensated for referring traffic and business to these companies. I dont think it has one. Has New battery and clean carb. Those are air, fuel, spark, and compression. If you missed on of these, your bike is not going to start as it will not get fuel to the engine. And I just replaced my neutral safety switch o ring and front blinkers and now wont start. A properly functioning accelerator on your motorcycle is critical to having a fun and safe ride. Make sure that the cylinders are not flooded as well. To test your spark plugs, remove them from the cylinder head and then plug them back into the plug cap. Thanks. The air box is off. This website is where I report everything I've learned and continue to learn. Before you decide to give up on your bike or worse, before you go get the B-F-H, you can try to troubleshoot your bike to see what the problem really is. Before I pulled the carbs out and cleaned them, my bike would turn over and fire up but now that I removed them and put them back in my bike wont stay running. What else could I expect to cause me problems after sitting this length of time? thank you. Any suggestions on how to get my baby running smoothly again? Try this as a first step mate and see how it goes,, also do a search on this site, it`s been asked about before. Kyle currently works as a mechanical engineer and graduated with a minor in automotive engineering. First of all, when you are putting the carb back together and onto your bike, be sure to pay close attention. If I turn the bike off. He loves restoring motorcycles, has a vast knowledge of how they work, and has sold his restoration projects to customers from all over the United States. Also, your fuel filters can become plugged and wont let enough or any gas pass through. Make sure the cables are operating smoothly as well. What are the disadvantages of shielding a thermometer? Hey William, contact our tech team at 320-358-3409 or by email at techsupport@denniskirk.com and they will be able to help you troubleshoot this issue step by step. If I turn on the fuel line, it floods out of the air filters. What else could be the problem.? Thanks Ryan, ill test out the bike with a new battery and see how it works out. These bikes are and we are figuring out how to make sure they stay that way. I have a 2008 Yamaha vstar 1100 with 7000 miles on it. Contact us:speedyautocc@outlook.com
Im getting gas an spark but wont start. Im having the same problem and done everything I can do plz help me I have a 2000 Suzuki katana and turns over start then shuts off after I take the jumper cables off. Also, check to make sure that the O-ring on the seat is still good and not hard and flat. Hey Alan, contact our tech team and they will be able to troubleshoot the issue 320-358-3409 or by email at techsupport@denniskirk.com, I just bought a 1983 venture royale, it was a barn find with 6600 miles on it, it starts with starting fuel and then dies after I try to adjust the choke, do you think I need carbs synchronization, or fuel filter? I rode it to work Saturday, Sunday, and yesterday. am having a problem with my motorcycle model type is honda baja250 Plugs seem to be dry but smell of old fuel even after draining tank and putting fresh fuel in. Today I was changing spark plug of my bike hero Honda street 100cc old modal.but I have force too high and inner part of plug break and set in the engine.remain part of plug come in my hand. Doing a good job on your cleaning is very important. The battery is brand new, I replaced it and kept a battery tender on it, and the engine turns over. Make sure that your key is turned to On or Run and that the kill switch is in the Run position as well. Not messaged, Your email address will not be published. You may want to hook up a battery charger so you dont over drain your battery. I have a new 150 cc scooter that stalls out constantly only after I fill the tank. This bike has only 29 miles on it. Got it home, leaked oil, started rough, kept stalling and smoking. Hi Tony, the first thing that you can check is your battery. Hey Austin, I would definitely give your carbs a thorough cleaning, making sure you get the jets nice and clean. Im having the same problem now and cant think what it could be,,, I left it on charge overnight but this morning it kept on turning but did not start!! My electrical start button starts the bike once. !!!!!!!!! Cdi? I try turning it over and over an No Spark! Ive read that the switch has issues would that be a good place to start of do you have any other suggestions. Drove great, ran out of gas while warming up. And as im righting this i M checking. Thank you sir. I thought the starter was out because it sounded like it was just spinning. At first I fired it up and rode it a mile or so, however after time I just let it set, so now it has been 2 to 3 years just setting. To un-flood the engine, you will need to remove the spark plugs. MessageHi, My bike starts well when the engine is cold and I can ride for about 1km then it runs off. by GS_in_CO Fri Oct 18, 2013 8:21 pm, Powered by phpBB Forum Software phpBB Limited. It will wind out.in neutral..but in gearunder load.NOPE. I turned it off then on again and there is no electricity going through the bike even though it has a brand new battery with a full charge. Bot a charger and hooked it up. Rocdahitman. Thanks. Hey Harry, contact our Tech Support Team and they will be able to help troubleshoot step by step to find the issue. Hi guys My cousin have custom built chopper 1800cc. Shut bike off let sit for a few minutes and tried re-starting. Ive tried with choke on and off. Do you have a lithium battery installed on the motorcycle? And have also replaced the rectifier. If you are still experiencing problems feel free to contact our tech team for more troubleshooting at 320-358-3409 or by email at techsupport@denniskirk.com. Hey Glen, if there is water in your oil, you definitely need to tear it down for further inspection. Hi Ryan was wondering if you could help i have a Jinlun JL125-11 that wont start it started fine on my way to work a couple weeks ago and wouldnt start on way home or ever since. I did get it running by jumping the solenoid yellow wire to the hot wire which turns the engine over, if I hold the starter button down at the same time Im jumping the solenoid the bike starts and runs beautiful. Again, started for a second and died. It will turn over for about a second or two and just die. The bike started for the first time after winter storage, I rode it for about 5 miles. please help, thank you. Hi Don, First you need to find out if the engine is turning over when the starter spins. Ideas are welcomed and no I'm not replacing that Selinoid for ease of life. Once they are removed, turn off the choke and turn the motor over until the excess gas has dissipated or if you have time, you can just let the bike sit until it evaporates. Not starting. Thank you. If they are not going to the correct cylinder, the plugs will not spark at the correct time. I unplugged the fuel line from the tank and cranked the bike, fuel came out. the motor crank but doesnt want to start.what could the problem be? Hello, I have a 1996 honda shadow 600. Unread post I have rebuilt carbs (2nd set actually, my mechanic buddy thought something was wrong with the set I had), all the seals been redone, new o-rings, float sets, float needles, floats, diaphragms are supple, not tears or pin holes, all passages cleaned and cleanedthey are nice. I just purchased a 2010 Suzuki GZ250 and it was running well for a month. I have an 07 ZX6R and she runs great! It sounds like a fuel delivery problem. any help would be awesome. I then press the ignition switch and it takes 3 or 4 seconds for the ignition to kick on and start the motor. Once your carbs are clean, you will want to make sure that your fuel pump is working properly as well. Jun 4, 2016. i would like to know if it helps anyone else please. Thank you! Rear carb releases no fuel. The carburetor has the important job of mixing the fuel and air before it enters the engine. One of my mechanic budseven did a compression test on cylinder 3 (I was having issues with it warming upealier in the rebuild process. Also check to make sure your crankcase vents are hooked up correctly and not clogged. Check your battery cables at to starter relay. I put premium gas in the tank and some seafoam. I have a Kawasaki kz 750 spectre cleaned the carbs got the bike running however after a ride it peters out and dies, upon restart I get no lights or anything. Hey Brandon, does it seem like the fuel is being pumped? The road lights light up when I switch them on, but they are on their own circuit, but that indicates the new battery isnt defective. However battery is fully charged. Compression tested too. Seems that gas is not making it to the McCooney carb or once gas makes it to the carb it still wont fire. I have a 1996 Yamaha Varago 1100 Is it possible the injectors are clogged as well. Theres only 3 or 4 lines but I havent found anyone who can help me put them back correctly. It stumbles to 115 and no matter how much throttle i give it its not going any faster. Drove bike in shop and parked it, bike hasnt started since. Make sure the needle/seat is clean and the float is working properly. )what to look for. Fresh gas can make a huge difference in your engines ability to start and run. The engine is turning over, but nothing is happening except for the fact that your frustration level is rising. Honda xr125L. SiteMap, Copyright 2005-2020 Speedy Auto All Rights Reserved, Motorcycle Repair: Charging Problem, test readings, signal lights, Motorcycle Repair: wet plug foul, yamaha rd 250, check air filter, Motorcycle Repair: size of flywheel puller, honda cb400n, metric scale, MotorcycleRepair:oilchange,bikebandit,yamaharadian, MotorcycleRepair:Gaspetcockonvirago500,virago500,bikebanditcom, Ford Repair: FORD GRANADA 1977, 1977 ford granada, vacuum leaks, UK Car Repair: VW golf 1.6 auto carb 1977, starts but dies, vw golf 1, crankcase breather, Volvo Repair: 1999 S70 Electrical Quirks, fuse box, electrical portion, Audio Systems: stereo problem, protection circuits, dear bill, Truck Repair: glow plugs, glowplugs, glow plugs, Ford Repair: blowing fuse, rear defroster, amp meter, Dodge: 97 dodge intrepid, advanced auto parts, intake plenum, Auto Insurance Claims: accident, own insurance, daughter lives.